Therefore, you can adopt different alternative methods according to the situation of your company, and use hydrocarbon double tank ultrasonic cleaning machine as much as possible to reduce your one-time investment. However, for any method, replacing ODS and other halogenated hydrocarbon cleaning agents with hydrocarbon cleaning agents will bring long-term economic benefits to the enterprise.

根据公司的碳氢双槽超声波清洗机类型、工艺要求、原始设备状况和资金实力，可以采用三种方法用碳氢双槽超声波清洗机代替原始清洗过程。

According to the type, process requirements, original equipment status and financial strength of the company's hydrocarbon double tank ultrasonic cleaning machine, three methods can be adopted to replace the original cleaning process with hydrocarbon double tank ultrasonic cleaning machine.

1、彻底更换设备。对于清洗能力大、设备陈旧、不符合清洗要求但允许资金条件的企业，可根据公司工艺要求，淘汰原有设备，设计制造碳氢双槽超声波清洗机。由于在设备上的大量投资，卤化烃清洗剂的日消耗量仅为五分之一或更少，资本投资在三年左右就可收回。

1. Completely replace the equipment. For enterprises with large cleaning capacity, outdated equipment, which do not meet the cleaning requirements but allow capital conditions, they can eliminate the original equipment and design and manufacture hydrocarbon double tank ultrasonic cleaning machine according to the company's process requirements. Due to the large investment in equipment, the daily consumption of halogenated hydrocarbon cleaning agent is only one-fifth or less, and the capital investment can be recovered in about three years.

2、部分更换设备。对于清洗工作量大、原有设备损坏比较大的公司，可将原有设备的气相清洗、干燥、蒸馏再生部分更换为碳氢双槽超声波清洗机。资金投入低，每天使用的清洗剂用量约为卤代烃清洗剂的40%，投入的设备资金一年左右回收。

2. Partial replacement of equipment. For companies with heavy cleaning workload and large damage to the original equipment, the gas-phase cleaning, drying and distillation regeneration of the original equipment can be replaced with hydrocarbon double tank ultrasonic cleaning machine. The capital investment is low. The amount of cleaning agent used every day is about 40% of that of halogenated hydrocarbon cleaning agent. The invested equipment funds are recovered in about one year.

3、部分更换设备。对于资金条件较差，可以继续使用原有清洗设备的企业，可将原有设备的自然干燥部分转化为具有循环水冷凝的热风干燥设备，并可增设碳氢双槽超声波清洗机，减少设备投资。清洗剂的日耗用量约为卤化烃清洗剂的1/2，投资设备资金约在10个月内收回。

3. Partial replacement of equipment. For enterprises with poor capital conditions that can continue to use the original cleaning equipment, the natural drying part of the original equipment can be transformed into hot air drying equipment with circulating water condensation, and hydrocarbon double tank ultrasonic cleaning machine can be added to reduce equipment investment. The daily consumption of cleaning agent is about 1 / 2 of that of halogenated hydrocarbon cleaning agent, and the capital invested in equipment will be recovered within about 10 months.